Cyclone separators are widely used in industrial applications. The separation efficiency and pressure drop are the most important parameters to evaluate the performance of processing system. In the simulations,the flow behavior of gas and particles within a square cyclone separator is simulated by means of computational fluid dynamics. The RNG k- ε model and the Reynolds stress model( RSM) are used to model gas turbulence. The flow behavior is examined in the term of tangential velocity components,static pressure and pressure drop contour plots for flow field and solid volume fraction. The effects of the turbulence model and solid volume fraction on the square cyclone are discussed. The results indicate that the pressure drop increases with the increase of solid volume fraction,and increase with the increase of inlet velocities for two turbulence models, moreover,the simulations results are compared with pressure field. For all runs,the RSM model gives a higher pressure drop compared to the RNG k- ε model. The RSM model provides well the forced vortex and free vortex,and captures better the phenomena occurring during intense vortex flow in the presence of walls within cyclone separators.
Noé-Landry-Privace M'BouanaFei-Xiang ZhaoQing-Hong ZhangHui-Lin Lu
This paper presents experimental and computational studies on the flow behavior of a gas-solid fluidized bed with disparately sized binary particle mixtures. The mixing/segregation behavior and segregation efficiency of the small and large particles are investigated experimentally. Particle composition and operating conditions that influence the fluidization behavior of mixing/segregation are examined. Based on the granular kinetics theory, a multi-fluid CFD model has been developed and verified against the experimental results. The simulation results are in reasonable agreement with experimental data. The results showed that the smaller particles are found near the bed surface while the larger particles tend to settle down to the bed bottom in turbulent fluidized bed. However, complete segregation of the binary particles does not occur in the gas velocity range of 0.695-0.904 m/s. Segregation efficiency increases with increasing gas velocity and mean residence time of the binary particles, but decreases with increasing the small particle concentration. The calculated results also show that the small particles move downward in the wall region and upward in the core. Due to the effect of large particles on the movement of small particles, the small particles present a more turbulent velocity profile in the dense phase than that in the dilute phase.
