Pipeline blockage by gas hydrates is a serious problem in the petroleum industry.Low-dosage inhibitors have been developed for its cost-effective and environmentally acceptable characteristics.In a 1.072-L reactor with methane,ethane and propane gas mixture under the pressure of about 8.5 MPa at 4 °C,hydrate formation was investigated with low-dosage hydrate inhibitors PVP and GHI1,the change of the compressibility factor and gas composition in the gas phase was analyzed,the gas contents in hydrates were compared with PVP and GHI1 added,and the inhibition mechanism of GHI1 was discussed.The results show that PVP and GHI1 could effectively inhibit the growth of gas hydrates but not nucleation.Under the experimental condition with PVP added,methane and ethane occupied the small cavities of the hydrate crystal unit and the ability of ethane entering into hydrate cavities was weaker than that of methane.GHI1 could effectively inhibit molecules which could more readily form hydrates.The ether and hydroxy group of diethylene glycol monobutyl ether have the responsibility for stronger inhibition ability of GHI1 than PVP.
TANG CuiPing 1,2,DAI XingXue 1,2,DU JianWei 1,2,LI DongLiang 1,2,ZANG XiaoYa 1,2,YANG XiangYang 1 & LIANG DeQing 1 1 Guangzhou Institute of Energy Conversion,Key Laboratory of Renewable Energy and Gas Hydrate,Chinese Academy of Sciences,Guangzhou 510640,China 2 Graduate University of the Chinese Academy of Sciences,Beijing 100039,China
